Sable car GAZ-2752, 2217, 2310>> Diagnostics of malfunctions>> Cabin and body

Cabin and body

Cause of defect

Elimination method

Dark stains on a body surface

Hit of particles of asphalt, bitumen on obverse surfaces (usually near wheel arches in the lower part of doors)

Remove bitumen «Cleaner of bitumen spots» or a similar preparation. It is impossible to apply gasoline or solvents. Insignificant damages заполируйте, at considerable damages recolour the damaged details of a body

The paint and varnish covering lost shine

Natural aging of a covering at long operation of the car

For care of the old car apply polishing pastes to weather-beaten coverings

Damage of a paint and varnish covering because of the wrong leaving: "dry" rubbing, application of rigid brushes at a sink, impact on a paint and varnish covering of solvents, etc.

Zapoliruyte the damaged places

Chips of a paint and varnish covering

Mechanical damage of a covering

Degrease the damaged place White-spiritom or solvent and tint repair enamel

Vspuchivaniye and otsloyeniye of a paint and varnish covering

Long influence of brake liquid, solvents, other aggressive liquids (electrolits, etc.) on a paint and varnish covering

Eliminate the reason of hit of aggressive liquids on a body surface, carefully wash out water of a place of damages, smooth out a skin, degrease White-spiritom or solvent, ground and tint

Corrosion of elements of a body, cabin

If the metal surface is struck only, smooth out a skin the damaged place, remove rust traces (a preparation for rust removal, according to the instruction to a preparation), degrease White-spiritom or solvent, ground and tint

Water gets into salon

The increased gap on door perimeter with a body (and also movable and back doors)

Adjust the provision of a door, the lock

The door sealant is put leaky on, its framework is crumpled
Water gets on consolidations of wind or back glasses

Densely put on a sealant, if necessary replace it. Miss the mark cracks with hermetic, a rust on a body smooth out and paint over (or cover with anticorrosive structure), the hardened or cracked sealant replace

Cooling liquid gets into salon

Leaks a heater radiator, weakened collars on hoses, hoses are faulty

Tighten collars, replace hoses, a radiator. Tightness of a radiator check in a bath with hot water, submitting in it air under the pressure of 1 kgf/cm2

The door is not closed

Jamming of mobile details of the lock

Grease details with getting WD-40 liquid. The deformed details correct or replace

The lock clamp (it is strongly shifted in an aperture) is not adjusted

Adjust the provision of a clamp

Violation of geometry of a body owing to blow or as a result of long operation under trying conditions

Address on HUNDRED, correct the deformed details, adjust locks of doors. Avoid fast movement on bad roads and car overloads

The door does not open and is not locked by a key

Water in the lock froze, dirt got to a larva

In cold weather use «Avtorazmorazhivatel of locks» in aerosol packing or a similar preparation. In warm weather grease the lock with getting WD-40 liquid

The core of the switch of the lock left gearing with the lever

Restore the gearing, the deformed details correct or replace, grease the lock with getting liquid

The door does not open the external handle

Draft of the handle left gearing with the lock lever, lock jamming

Restore the gearing, the deformed details correct or replace, grease the lock with engine oil

The door knocks at car movement

Jamming of a cracker of a clamp or breakage of its spring

Clear a clamp of dirt and old greasing, grease it Litolom-24. The broken spring replace

The lateral door leaves gearing with directing

It is broken, погнута directing or an axis of one of rollers, the roller is lost

Replace details

The door is badly locked

Door distortion

Adjust the provision of a door

The lock of a cowl does not open the handle from salon

Break of draft of a drive of the lock

Replace draft

The tip is disconnected from draft

Put on a tip

The length of draft of a drive of the lock is great

Adjust length of draft

The handle of unlocking of the lock of a cowl does not come back to a starting position

Jamming of a clamp of the lock

Adjust the lock, having achieved coaxiality of its opening with a clamp

Breakage of a spring of the lock of a cowl

Replace a spring

The cowl is not locked

The lock spring is broken or weakened

Replace drafts or the lock

Draft of a drive of the lock is short

Adjust length of draft

Wrong adjustment of the lock

Adjust the lock

Opusknoye glass is not fixed in a standard position

The window regulator mechanism is broken

Replace a window regulator

Glass moves only in one direction

The window regulator cable is torn off

Replace a window regulator

The effort on the window regulator handle is great

The door frame is deformed

Correct or replace a door

Breakage of the mechanism of a window regulator

Replace a window regulator

The handle of a window regulator rotates, but glass is motionless

Break of a cable of a window regulator

Replace a cable

Shlitsa on the window regulator handle are broken

Replace the handle

Adjustment of an inclination of a back, seat moving is complicated

Wear of the mechanism of adjustment of an inclination of a back, breakage or wear of the mechanism of moving of a seat (sled)

Replace details, grease a sled